1990 died on me riding done the road


Information and questions on GL1500 Goldwings (1988-2000)
  • Sponsored Links
dalejr88
Posts: 7
Joined: Sun Sep 18, 2011 9:00 am
Location: st.cloud,fla
Motorcycle: 1990 goldwing,2004honda shadow aero,79kz1000

1990 died on me riding done the road

Postby dalejr88 » Sun Jun 30, 2013 8:21 pm



let me start by saying this web site is THE best ive seen on goldwings,you guys & gales are so helpful to all bike riders its un belivable . ok enough butt kissing . I have a 1990 Goldwing only had it about three years ive done a lot of work on it myself,a week ago went for a ride went about 80 miles got caught in the rain drove threw it went another 10 miles bike stop running , coasted to the side of the road tried to start it engine turns over wont start. trailered it home checked fuses, relays have notice cruise light not on on the dash help any ideas would be greatly appreciated thanks



User avatar
ct1500
Posts: 813
Joined: Wed Nov 10, 2010 8:09 pm
Location: Glastonbury,CT
Motorcycle: 1988 GL1500
Contact:

Re: 1990 died on me riding done the road

Postby ct1500 » Sun Jun 30, 2013 9:36 pm

The cruise on light not illuminating with key on and cruise button in tells you the ECM is not getting power. Side stand and neutral lights work, right. Check ign/cruise 15A fuse (no. 2) I think. Then swap relay (8) I think with another one if the cruise on light comes on you found your problem. If not next item to check is the kill switch,both wires should be hot in run position.
This is what I do
Local and need repair help with your 1500, Valkyrie or ST please PM

dalejr88
Posts: 7
Joined: Sun Sep 18, 2011 9:00 am
Location: st.cloud,fla
Motorcycle: 1990 goldwing,2004honda shadow aero,79kz1000

Re: 1990 died on me riding done the road

Postby dalejr88 » Mon Jul 01, 2013 4:57 am

will check kill switch for power ,did find #7 fuse has no power thanks for the info

Ruaidh
Posts: 2
Joined: Mon Jun 21, 2010 4:07 pm
Location: Layton,UT
Motorcycle: 1990 GL1500

Re: 1990 died on me riding done the road

Postby Ruaidh » Mon Jul 01, 2013 9:57 am

My '90 Wing did that on and off for a while. Died then would suddenly start to work again. Discovered that there is a common joint on the wiring harness under the faux tank on the left side of the frame. Apparently, it is a point where all (a lot of) the ground wires run to/through. At some point it poked through the covering and was grounding out the bike. Choice was to replace the entire harness or cut out the dead spot and re-build. Cheaper and faster to excise the dead spot and I was on the road again later that day.

dalejr88
Posts: 7
Joined: Sun Sep 18, 2011 9:00 am
Location: st.cloud,fla
Motorcycle: 1990 goldwing,2004honda shadow aero,79kz1000

Re: 1990 died on me riding done the road

Postby dalejr88 » Mon Jul 01, 2013 10:11 am

I will check that too when I get home tonight thanks for info

dalejr88
Posts: 7
Joined: Sun Sep 18, 2011 9:00 am
Location: st.cloud,fla
Motorcycle: 1990 goldwing,2004honda shadow aero,79kz1000

Re: 1990 died on me riding done the road

Postby dalejr88 » Mon Jul 01, 2013 8:45 pm

ct 1500 you were right on the money it was the kill switch , I check power only on one side of the switch removed the switch hook the two wires together she fired right up .put a piece of heat shrink tube on it temporary till I can get a new switch. after I got it running I went back and check the number 7 fuse I still only have .33 volts on both sides of the fuse ,can anyone tell me what that fuse supplys power too thanks for the replys

User avatar
ct1500
Posts: 813
Joined: Wed Nov 10, 2010 8:09 pm
Location: Glastonbury,CT
Motorcycle: 1988 GL1500
Contact:

Re: 1990 died on me riding done the road

Postby ct1500 » Mon Jul 01, 2013 11:40 pm

7 fuse is parking I think and will only get power when key is turned backwards to parking position with taillight burning.
This is what I do
Local and need repair help with your 1500, Valkyrie or ST please PM

dalejr88
Posts: 7
Joined: Sun Sep 18, 2011 9:00 am
Location: st.cloud,fla
Motorcycle: 1990 goldwing,2004honda shadow aero,79kz1000

Re: 1990 died on me riding done the road

Postby dalejr88 » Tue Jul 02, 2013 3:39 am

Ok thanks didn't know thought I still had a problem I will check that and let you know

User avatar
virgilmobile
Posts: 7663
Joined: Sun Sep 19, 2010 5:39 pm
Location: Denham Springs,La.
Motorcycle: 1988 GL1500 I
Previously owned
78 GL1000
81 GL1100
82 GL1100 I
83 GL1100 I
83 GL1100 standard
84 GL 1200 I

Re: 1990 died on me riding done the road

Postby virgilmobile » Tue Jul 02, 2013 6:55 am

If your gonna replace the switch,you could practice repairing the one you have.
They disassemble fairly easily and should clean up fine.Stretch the spring just a touch too.You may end up with a spare.

dalejr88
Posts: 7
Joined: Sun Sep 18, 2011 9:00 am
Location: st.cloud,fla
Motorcycle: 1990 goldwing,2004honda shadow aero,79kz1000

Re: 1990 died on me riding done the road

Postby dalejr88 » Tue Jul 02, 2013 8:04 am

After leaving me on the side of the road I would rather replace it with a new one for my confedance besides I have fingers like clubs don't do good working on small things :(

dalejr88
Posts: 7
Joined: Sun Sep 18, 2011 9:00 am
Location: st.cloud,fla
Motorcycle: 1990 goldwing,2004honda shadow aero,79kz1000

Re: 1990 died on me riding done the road

Postby dalejr88 » Tue Jul 02, 2013 8:14 am

I had a feeling the switch had something to do with my problem from the start just wasn't shore how to check it , told my buddy I ride with sometimes when I ate my cruise I would rest my hand on top of the right handle bar the kill switch would be warm to the touch I didn't know it had power running to it I Gus's I should have check it sooner and it would not left me on the side of the road leave and learn




Return to “GL1500 Information & Questions”




Who is online

Users browsing this forum: CrystalPistol, Google Adsense [Bot], mburmandds and 5 guests