alternator charging???


Information and questions on GL1500 Goldwings (1988-2000)
  • Sponsored Links
User avatar
vtxcandyred
Posts: 517
Joined: Thu Dec 31, 2009 5:08 pm
Location: Oregon, Ohio
Motorcycle: 1993 Honda Goldwing SE

alternator charging???

Postby vtxcandyred » Thu Jun 23, 2016 4:32 am



Not good at liking things up. The battery discharges. I will have it tested but I want to test the alternator. I have a Radio shack cheapy meter. It appears as though I have under twelve volts at the battery with the bike running above idle and about twelve to almost thirteen volts key off. Engine running above idle I turn on different things to add load and the voltage drops little. Fully charged I can drive it about ten miles when I see the change in available power and it weakens from there. Charge the battery and it starts all over again. Battery is less than three years old. By the way the bike can sit for a VERY long time and it spins the motor right away with no hesitation.



User avatar
Dusty Boots
Posts: 573
Joined: Mon Oct 26, 2009 4:25 pm
Location: Alvinston, SW ON
Motorcycle: 1992 GL1500Aspencade

Re: alternator charging???

Postby Dusty Boots » Thu Jun 23, 2016 6:56 am

Time for either servicing the alternator, or a new one. ;)

Dusty

User avatar
RBGERSON
Posts: 2621
Joined: Tue Mar 09, 2010 7:57 am
Location: SCOTTSDALE, AZ
Motorcycle: 98 SE GL 1500
had every year from 75 to 83

Re: alternator charging???

Postby RBGERSON » Thu Jun 23, 2016 8:40 am

At idle turn at about 800 you should see 12v's on a meter at the battery.

at 3,000 rpm's you should see 13.5 or so depending on what's turned on..that's what you "need" to keep the battery charged while running..actually 12.5 will keep it charged and running. but 13.5 is ideal. Over 14.5 also bad, can fry wet batteries; Ok for AGM batteries. that's usually a regular issue over charging.

less could be bad alternator, bad connections, bad regulator. bad battery/cell
HAD LOTS OF GOLDWING 75-83
NOW INTO 1500'S..RIDING A 1998 SE

FAIR WINDS,
RB

User avatar
keithg64
Posts: 339
Joined: Thu May 21, 2009 9:47 pm
Location: Geneseo, IL
Motorcycle: 2000 GL1500 Pearl Coranado Blue

Re: alternator charging???

Postby keithg64 » Thu Jun 23, 2016 9:41 am

Could be that the brushes are worn out and need replacing. Not a hard job, a local alternator shop can tell you.
It's not what you buy, it's what you build.

User avatar
MikeB
Posts: 1225
Joined: Fri Dec 04, 2009 12:54 pm
Location: Tacoma, WA
Motorcycle: 1998 - GL1500 Aspencade.
2003 - GL1800A

Re: alternator charging???

Postby MikeB » Thu Jun 23, 2016 12:44 pm

If it is a 1993, then it is most likely the brushes. I have not heard of winding failures on '95 and older alternators.

Remove the alternator. If you are so inclined, disassemble it and replace the brushes. If you are not the mechanical type, take it to an alternator shop and have them do it.

Reinstall it and test again. It will most likely be just fine.


MikeB
Tacoma, WA, USA


Return to “GL1500 Information & Questions”




Who is online

Users browsing this forum: harvey01 and 5 guests