How to "read" used spark plugs

Information and questions on GL1800 Goldwings (2001-2017)
Post Reply
User avatar
Site Admin
Posts: 23585
Joined: Fri Oct 03, 2008 4:16 pm
Location: Strongsville, OH
Motorcycle: 2000 GL1500 SE
1982 GL1100A Aspencade (sold)
1989 PC800 (sold)
1998 XV250 Virago (sold)
2012 Suzuki Burgman 400 (wife's!)
2007 Aspen Sentry Trailer

How to "read" used spark plugs

Post by WingAdmin »

Your spark plugs can give you a lot of information as to how well your engine is running, and predict problems that are occurring long before you identify any other symptoms. Make it a habit of looking closely at your spark plugs every time you remove or change them. Here's what you can be looking for:

Brown to grayish-tan color and slight electrode wear. Correct heat range for engine and operating conditions.

Symptoms: Rounded electrodes with small amount of deposits on the firing end. Normal color. Causes hard starting in damp or cold weather and poor fuel economy. Plugs have been left in the engine too long. Replace with new plugs of the same heat range.

Carbon Deposits
Symptoms: Dry, sooty deposits indicating a rich mixture or weak ignition. Causes misfiring, hard starting and hesitation. Make sure the plug has the correct heat range. Check for a clogged air filter or problem in the fuel system. Also check for ignition system problems.

Ash Deposits
Symptoms: Light brown deposits encrusted on the side or center electrodes or both. Derived from oil and/or fuel additives. Excessive amounts may mask the spark, causing misfiring and hesitation during acceleration. If excessive deposits accumulate over a short time or low mileage, install new valve guide seals to prevent seepage of oil into the combustion chambers. Also try changing gasoline brands.

Oil Deposits
Symptoms: Oily coating caused by poor oil control. Oil is leaking past worn valve guides or piston rings into the combustion chamber. Causes hard starting, misfiring and hesitation. Blue smoke will be seen coming from exhaust. Correct the mechanical problem causing the condition and install new plugs.

Gap Bridging
Symptoms: Combustion deposits lodge between the electrodes. Heavy deposits accumulate and bridge the electrode gap. The plug ceases to fire, resulting in a dead cylinder. Remove the deposits from between the electrodes.

Too Hot
Symptoms: Blistered, white insulator, eroded electrode and absence of deposits. Results in shortened plug life. Check for the correct plug heat range, over-advanced ignition timing, lean fuel mixture, intake manifold vacuum leaks, sticking valves and insufficient engine cooling.

Symptoms: Melted electrodes. Insulators are white, but may be dirty due to misfiring or flying debris in the combustion chamber. Can lead to engine damage. Check for the correct plug heat range, over-advanced ignition timing, lean fuel mixture, insufficient engine cooling and lack of lubrication.

High Speed Glazing
Symptoms: Insulator has yellowish, glazed appearance. Indicates that combustion chamber temperatures have risen suddenly during hard acceleration. Normal deposits melt to form a conductive coating. Causes misfiring at high speeds. Install new plugs. Consider using a colder plug if driving habits warrant.

Symptoms: Insulators may be cracked or chipped. Improper gap setting techniques can also result in a fractured insulator tip. Can lead to piston damage. Make sure the fuel octane is high enough. Use care when setting the gaps on new plugs. Avoid lugging the engine.

Mechanical Damage
Symptoms: May be caused by a foreign object in the combustion chamber or the piston striking an plug that is too long. Causes a dead cylinder and could result in piston damage. Repair the damage and correct the cause.

Coolant Leak/Head Gasket
Symptoms: Coolant is entering the cylinder, either through a leaking/failed head gasket, or a cracked block. The coolant "steam cleans" the plug, so the plug appears clean and shiny.

Incorrect carburetor mixture can also be seen on spark plugs:

Incorrect Mixture Results
Incorrect Mixture Results

Some more examples:

Spark plug examples
Spark plug examples

User avatar
Posts: 577
Joined: Mon Feb 14, 2011 11:21 pm
Location: San Antonio,TX
Motorcycle: 98 Goldwing 1500 trike
75 GL1000 (restoring)
98 Goldwing with landing gear (for sale)
94 Goldwing 1500- towpac trike (sold)
88 Goldwing 1500- (sold)
84 GL1200 Aspy-SOLD
75 GL1000(stolen 87)
88 GW trike (totaled)
1972 750k2

Re: How to "read" used spark plugs

Post by twostrokes48 »

great chart to have handy, maybe move it somewhere easy to find, maybe nu a dyi tuneup or something...just a thought.
Post Reply