Occasional Fuel Leak from Vent Hose at #3 Carb

Information and questions on GL1100 Goldwings (1980-1983)
Post Reply
Posts: 24
Joined: Wed Dec 31, 2014 10:33 am
Location: Villa Hills, KY
Motorcycle: 1981 GL1100
1982 Honda CB900C - SOLD

Occasional Fuel Leak from Vent Hose at #3 Carb

Post by Josterhage »

I have an occasional fuel leak from the connection for the vent hose where it attaches to the #3 carb on my 81 GL1100. This appears to only happen while the bike is parked, it was cold the night before, and I forgot to shut the petcock off. Once I have shut the petcock off and the temp warms up the leak stops. Looking for possible causes.

User avatar
Mr moe
Posts: 41
Joined: Sat Feb 20, 2016 6:34 pm
Location: L'Orignal, ON Canada
Motorcycle: GL1100A Aspencade '82
GL1100I Interstate '83

Re: Occasional Fuel Leak from Vent Hose at #3 Carb

Post by Mr moe »

The "vent" hose is actually a drain hose to drain any excessive fuel in the carb.
The needle valve on that carb may be leaking causing the high level of fuel.
Or possibly the float level is set too high on that carb.
Always, always shut fuel tap off when not in use.
Present rebuild 1982 GL1100A Goldwing

Don't part them out ---- Restore them.
User avatar
Posts: 3233
Joined: Tue Mar 09, 2010 7:57 am
Motorcycle: 98 SE GL 1500
had every year from 75 to 83

Re: Occasional Fuel Leak from Vent Hose at #3 Carb

Post by RBGERSON »

I didn't think there were any "vent/drain hoses on Gl1100 or gl1000 carbs but #3 does have a vacuum hose that goes to the pulse generator. if the carbs leak the gas goes into the cylinders and then oil pan.. shouldn't have to shut petcock off if the carbs are working correctly but it is a good safe guard in case they are not. As one can bend a rod if you get hydrolocked..

User avatar
Posts: 318
Joined: Sat Oct 12, 2013 7:00 am
Location: Pittsburgh, Pennsylvania
Motorcycle: 83 Goldwing Interstate

Re: Occasional Fuel Leak from Vent Hose at #3 Carb

Post by Overdog »

I was thinking the same thing....no overflow tubes/hoses. A leak at carb #3 could be from the accelerator pump. If the diaphragm fails gas will travel up the shaft and leak from the carb body....I had this happen. The symptoms were different though....I kept smelling gas when I was riding but couldn't find evidence of a leak. After some time it got bad enough that the carb was wet. I was looking at the carb with a flashlight when I twisted the throttle...that's when I spotted the exact problem

Post Reply